PARTS AND OPERATION MANUAL
MULTIQUIP
Model GA-6HZ
A.C. GENERATOR
Revision #4 (10/08/04)
MULTIQUIPINC.
18910 WILMINGTON AVE.
PARTS DEPARTMENT:
800-427-1244
CARSON, CALIFORNIA 90746 FAX: 800-672-7877
310-537-3700
800-421-1244
SERVICE DEPARTMENT/TECHNICAL ASSISTANCE:
800-478-1244
FAX:310-537-3927
FAX:310-631-5032
Atlanta • Boise • Dallas • Houston • Newark
Montreal, Canada • Manchester, UK
Rio De Janiero, Brazil • Guadalajara, Mexico
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE 2 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HERE'S HOW TO GET HELP
PLEASE HAVE THE MODEL AND SERIAL NUMBER
ON-HAND WHEN CALLING
PARTS DEPARTMENT
800-427-1244 or 310-537-3700
FAX: 800-672-7877 or 310-637-3284
SERVICE DEPARTMENT/TECHNICAL ASSISTANCE
800-478-1244 or 310-537-3700
FAX: 310- 537-4259
WARRANTY DEPARTMENT
888-661-4279, or 310-661-4279
FAX: 310- 537-1173
MAIN
800-421-1244 or 310-537-3700
FAX: 310-537-3927
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 3
Download from Www.Somanuals.com. All Manuals Search And Download.
TABLE OF CONTENTS
Here's How To Get Help ............................................ 3
Table Of Contents ..................................................... 4
Parts Ordering Procedures ....................................... 5
Rules For Safe Operation ......................................... 6
Operation and Safety Decals .................................... 7
HondaGX340K1Engine
Cylinder Head Assembly....................................36-37
Recoil Starter Assembly.....................................38-39
Fan Cover Assembly ..........................................40-41
Camshaft/Valves Assembly................................42-43
Piston/Rings Assembly.......................................44-45
Air Cleaner Assembly.........................................46-47
Cylinder Barrel (Recoil) Assembly .....................48-49
Cylinder Barrel (Electric) Assembly ...................50-51
Crankcase Cover/Governor Assembly ..............52-53
Flywhee/Fan Assembly ......................................54-55
Coil Assembly.....................................................56-57
Crankshaft Assembly .........................................58-59
Electric Start Assembly ......................................60-61
Governor Controls Assembly .............................62-63
Carburetor Assembly .........................................64-65
Solenoid Assembly.............................................66-67
Fuel Cock Assembly ..........................................68-69
Specifications ............................................................ 8
General Information .................................................. 9
Multiquip GA-6HZ— AC
Generator
Controls and Indicators ........................................... 10
Installation ............................................................... 11
Pre-Setup ........................................................... 12-13
Instrumentation ....................................................... 14
Load Application ..................................................... 15
Operating Instructions............................................. 16
Maintenance ........................................................... 17
Preparation For Long Term Storage ....................... 18
Wiring Diagram ....................................................... 19
Troubleshooting (Engine)................................. 20-221
Troubleshooting (Generator) ............................. 22-23
Explanation Of Codes In Remarks Column ............ 24
Suggested Spare Parts ........................................... 25
Generator Assembly .......................................... 26-27
Control Box Assembly ........................................ 28-29
Pipe Frame Assembly ........................................ 30-31
Muffler Assembly ............................................... 32-33
Nameplate Assembly ......................................... 34-35
Terms and Conditions Of Sale — Parts .................. 70
NOTE
Specification and part number
are subject to change without
notice.
PAGE 4 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS ORDERING PROCEDURES
■ Dealer account number
■ Dealer name and address
■ Shipping address (if different than billing address)
■ Return fax number
■ Applicable model number
■ Quantity, part number and description of each part
■ Specify preferred method of shipment:
UPS Ground
•
UPS Second Day or Third Day*
•
UPS Next Day*
•
Federal Express Priority One (please provide us with your Federal
Express account number)*
•
Airborne Express*
•
Truck or parcel post
•
*Normally shipped the same day the order is received, if prior to 2PM west coast time.
Earn Extra Discounts when
you order by FAX!
All parts orders which include complete part numbers
and are received by fax qualify for the following extra
discounts:
Number of
line items ordered
Additional Discount
1-9 items
3%
10+ items**
5%
Get special freight allowances
when you order 10 or more
line items via FAX!**
Now! Direct TOLL-FREE access
to our Parts Department!
■
UPS Ground Service at no charge for freight
■
PS Third Day Service at one-half of actual freight cost
Toll-free nationwide:
800-421-1244
No other allowances on freight shipped by any other carrier.
**Common nuts, bolts and washers (all items under $1.00 list price)
do not count towards the 10+ line items.
Toll-free FAX:
*DISCOUNTS ARE SUBJECT TO CHANGE*
800/6-PARTS-7 • 800-672-7877
Fax order discount and UPS special programs revised June 1, 1995
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 5
Download from Www.Somanuals.com. All Manuals Search And Download.
RULES FOR SAFE OPERATION
■
Provide adequate ventilation when operating the generator.
DO NOT operate the generator in any enclosed or narrow
space. The generator's gasoline engine gives off DEADLY
carbon monoxide gas.
CAUTION:
Failure to follow instructions in this manual
may lead to serious injury or even death!This
equipment is to be operated by trained and
qualified personnel only! This equipment is
for industrial use only.
■
■
■
■
NEVER operate the generator in an explosive atmosphere or
near combustible materials. An explosion or fire could result
causing severe bodily harm or even death.
The following safety guidelines should always be used when
operating the GA-6HZRGenerator:
Always make sure that the generator is secure on level ground
so that it cannot slide or shift around, endangering workers.
Also keep the immediate area free of bystanders.
GENERAL SAFETY
■
■
■
DO NOT operate or service this equipment before reading
When using a concrete vibrator or a similar device that is
immersed in a water based solution, make sure the device is
equipped with short circuit protection.
this entire manual.
This equipment should not be operated by persons under 18
years of age.
Always use rubber boots and gloves when operating a
concrete vibrator or similar device.
NEVER operate this equipment without proper protective
clothing, shatterproof glasses, steel-toed boots and other
protective devices required by the job.
■
■
Use adequate size connecting cable for extension.
■
This generator is a source of potentially LETHAL high voltage.
Never permit unqualified personnel-especially children to
operate the generator.
Maintain electrical cords in good condition and frequently
replace the entire cable of the concrete vibrator with a new
one.
■
■
Always refuel in a well-ventilated area, away from sparks and
open flames.
■
HighTemperatures – Allow the machine and engine to cool
before adding fuel or performing service and maintenance
functions. Contact with hot components can cause serious
burns.
Always use extreme caution when working with flammable
liquids. When refueling, stop the engine and allow it to cool.
DO NOT smoke around or near the machine. Fire or explosion
could result from fuel vapors, or if fuel is spilled on a hot
engine.
Emergencies
■
Always know the location of the nearest fire extinguisher
and first aid kit. Know the location of the nearest telephone.
Also know the phone numbers of the nearest ambulance,
doctor and fire department. This information will be
invaluable in the case of an emergency.
■
■
This generator is equipped with a ground terminal for your
protection. Always complete the grounding path from the
generator to an external grounding source.
NEVER operate this generator, or handle any electrical
equipment while standing in water, while bare foot, while
hands are wet, or in the rain. Electrical shock could occur
causing severe bodily harm or even death.
Maintenance Safety
■
NEVER lubricate components or attempt service on a running
machine.
■
Always allow the machine a proper amount of time to cool
before servicing.
■
■
Keep electrical cords in good condition. Worn, bare or frayed
wiring can cause electrical shock, leading to bodily harm or
even death.
■
■
Keep the machinery in proper running condition.
Fix damage to the machine immediately and always replace
broken parts.
This generator requires an adequate free flow of cooling air.
Never operate the generator in any enclosed or narrow area
where free flow of the air is restricted. If the air flow is restricted
it will cause serious damage to the generator and may cause
injury to people.
■
■
■
Dispose of hazardous waste properly.Examples of potentially
hazardous waste are used motor oil, fuel and fuel filters.
DO NOT use food or plastic containers to dispose of
hazardous waste.
■
NEVER touch the hot exhaust manifold, muffler or cylinder.
Allow these parts to cool before servicing generator.
DO NOT pour waste, oil or fuel directly onto the ground,
down a drain or into any water source
PAGE 6 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION AND SAFETY DECALS
Machine Safety Decals
The GA-6HZ portable generator is equipped with a number of safety decals.These decals are provided for operator safety and
maintenance information.The illustration below shows these decals as they appear on the machine. Should any of these decals
become unreadable, replacements can be obtained from your dealer.
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 7
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— SPECIFICATIONS
Table 1. Specifications
MODEL
GA-6HZ
Type
2-pole, Brushless Type Revolving Field
Max. Output
Rated Output (continuous)
Rated Voltage
Rated Current
Phase
5500 Watts
5000 Watts
120/240 V
21 Amps
60 Cycle Generator
Single Phase (4-wire)
60 Hz
Frequency
Rated Speed
Power Factor
Model
3600 RPM
100%
Honda GX340K1VD
Air-cooled 4 stroke OVH 90 V- Twin
horizontal shaft gasoline engine
Type
Bore X Stroke
Displacement
Max Output
1-3.23 in. X 2.52 in.
20.63 cc
11 H.P./3600 R.P.M.
Approx. 5 U.S. Gallons
Unleaded Automobile Gasoline
2 1/3 pints
Engine
Fuel Tank Capacity
Fuel
Lube Oil Capacity
Speed Control Method
Starting Method
Centrifugal Fly-weight Type
Recoil/Electric Start
780 X 515 X 480 mm
216 lbs (98 Kg.)
Dimension (LXWXH)
Dry Net Weight
Effects of Altitude and Heat
The maximum output of the engine listed above is applicable to supplying electrical power for continuous service at ambient
conditions in accordance with SAE Test cord J607. The above ambient conditions are at standard sea level, with a barometric
reading of 29.92 inches and a temperature of 60 degrees fahrenheit.
Generally, the engine output power will decrease 3 1/2% for each 1000 feet of altitude above sea level, and 1% for each 10° F
fahrenheit above the standard temperature of 60° F
PAGE 8 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— GENERAL INFORMATION
Excitation System
WARNING:
All GA-series generators use a magnet attached to a flywheel
to produce AC voltage from a lamp coil beneath the flywheel.
As the magnet passes the coil it produces approximately
19-22 AC volts.
Before connecting this generator to
any building’s electrical system, a
licensed electrician must install an
isolation (transfer) switch.
This voltage (19-22 VAC) is then sent to the control box that
contains three rectifying diodes:
Serious injury or death may result
without this transfer switch.
z
z
z
Excitation (diode 1)
Battery (diode 2)
Slow Down (diode 3)
GA-6HZ FAMILIARIZATION
Generator
The AC voltage will pass through the excitation diode that
converts the voltage to DC power.
The Multiquip Model GA-6HZ generator has been designed
as a portable lightweight power source for 60 Hz (single-
phase) vibrators, lighting facilities, power tools, submersible
pumps and other industrial and construction machinery.
This DC power is then sent to the excitation windings housed
within the main windings commonly called the "stator".
This generator is powered by a HONDA gasoline engine.
The alternator, a brushless revolving-field type, is
permanently aligned to the engine through rigid coupling.
This voltage is then transferred into the rotor through
induction.The rotor contains two diodes within it which rectify
the DC voltage and send it out through the main windings,
as AC voltage.
The generator is mounted on rubber vibration isolators that
have a steel base backplate which is attached to the
protective steel pipe carrying frame.The protective carrying
frame is made of steel tubing and fully wraps around the
generator to protect against damage.
Engine
The four-cycle air-cooled HONDA gasoline engine is designed
to meet every performance requirement of this generator.
Reference Table 1, page 8 for engine specifications.
This portable generator is supplied with a electrical control
box. To reduce vibration caused by the engine, the control
box is also placed on rubber isolators.
Figure 1 (page 10) shows the basic controls and indicators
for the GA-6HZ generator.
Control Box
The control box has the following: (all outputs are 60 Hz,
single phase)
NOTE
z
z
z
z
z
z
z
z
One 120V output receptacle.
One 240V output receptacle.
One 120V output receptacle (GFI protected).
One main 21 amp circuit breaker.
AC Voltmeter
In keeping with Multiquip's policy of
constantly improving its products, the
specifications quoted herein are subject
to change without prior notice.
Idle Control Switch
Full Power Switch
Operation Switch
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 9
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ — CONTROLS AND INDICATORS
Figure 1. Controls and Indicators
PAGE 10 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— INSTALLATION
Outdoor Installation
Install the generator in a location where it will not be exposed to Exhaust gases from gasoline engines are extremely
Indoor Installation
rain or sunshine. Make sure that the generator is on secure level
ground so that it cannot slide or shift around. Also install the
generator in a manner so that the exhaust will not be discharged
in the direction of nearby homes.
poisonous. Whenever an engine is installed indoors the
exhaust fumes must be vented to the outside. The engine
should be installed at least two feet from any outside wall.
Using an exhaust pipe which is too long or too small can
cause excessive back pressure which will cause the engine
to heat excessively and possibly burn the valves.
The installation site must be relatively free from moisture and
dust. All electrical equipment should be protected from excessive
moisture.Failure to do will result in deterioration of the insulation
and will result in short circuits and grounding.
Eliminate the danger of deadly carbon monoxide gas.
Remember that exhaust fumes from any gasoline engine
are very poisonous if discharged in a closed room, but
harmless if allowed to mix with the outside air.If the generator
is installed indoors, you must make provisions for venting
the engine exhaust to the outside of the building.
Foreign materials such as dust, sand, lint and abrasive materials
have a tendency to cause excessive wear, not only to the engine
parts, but also to the alternator parts.
CAUTION :
CAUTION :
An electric shock is apt to happen when
vibrators are used. Pay close attention to
handling when operating vibrators and
always use rubber boots and gloves to
insulate the body from a short circuit.
Pay close attention to ventilation when
operating the generator inside confined
areas. The engine exhaust contains
noxious elements.
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 11
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— PRE-SETUP
General Inspection Prior to Operation
Circuit Breaker
This generator has been thoroughly inspected and accepted To protect the generator from an overload, a 2-pole 13.5 amp
prior to shipment from the factory.However, be sure to check circuit breaker is provided on the control box. Make sure to
for damaged parts or components, or loose nuts and bolts, switch this circuit breaker to the "OFF" position prior to
which could have occurred in transit.
starting the engine.
Ground
Extension Cable
When electric power is to be provided to various tools or loads at
some distance from the generator, extension cords are normally
used. Cables should be sized to allow for distance in length and
amperage so that the voltage drop between the generator and
point of use (load) is held to a minimum. Use the cable selection
chart (Table 2 ) as a guide for selecting proper cable size.
The nut and ground terminal on the generator should always
be used to connect the generator to a suitable ground. The
ground path should be of #8 size wire.
Connect the terminal of the ground wire between the lock
washer and the nut and tighten the nut fully. Connect their
end of the wire to a suitable ground.
Table 2. Cable Selection (60 Hz, single phase operation)
Load In Watts
At 120 At 240
Maximum Allowable Cable Length
Current
in
Amperes
#10 Wire
#12 Wire
#14 Wire
#16 Wire
Volts
Volts
2.5
5
300
600
1000 ft.
500 ft.
350 ft.
250 ft.
150 ft.
125 ft.
600 ft.
300 ft.
200 ft.
150 ft.
100 ft.
75 ft.
375 ft.
200 ft.
125 ft.
100 ft.
65 ft.
250 ft.
125 ft.
100 ft.
600
1200
1800
2400
3600
4800
7.5
10
15
20
900
1200
1800
2400
50 ft.
CAUTION: Equipment damage can result from low voltage.
PAGE 12 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— PRE-SETUP
Fuel
Lubrication Oil
Close the fuel cock before filling the tank. Fill the fuel tank
with clean and fresh unleaded gasoline. Do not fill the tank
beyond capacity.
Fill the engine crankcase with lubricating oil through the filler
hole, but do not overfill. Make sure the generator is level.
With the dipstick inserted all the way, but without being screw
into the filler hole, verify that the oil level is maintained
between the two notches on the dipstick.
Pay attention to the fuel tank capacity when replenishing
fuel. Refer to the fuel tank capacity listed on page 8
Specification Table1.
The oil listed in Table 3 is recommended to ensure better
engine performance. Use class SC or higher grade motor
oil.
The fuel tank cap must be closed tightly after filling.
Handle fuel in a safety container. If the container does not have
a spout, use a funnel.
NOTE
This HONDA engine is equipped with a low oil
shutdown capability. A built in sensor will
automatically turn off the engine should the oil level
fall below a safe operating condition. Make sure
the generator is placed on level ground. Placing
the generator on level ground will ensure that the
low oil sensor will function properly.
CAUTION :
Never fill the fuel tank while the engine is
running or in the dark. Gasoline spillage
on a hot engine can cause a fire or
explosion. If gasoline spillage occurs, wipe
Table 3. Recommended Motor Oil
Temperature
Range
Type Oil
SAE 30
104° F ~ 23° F
(40° C ~ -5°C)
23° F ~ 5° F
(-5° C ~ -15°C)
SAE 20 or SAE 10W-30
SAE 10W or SAE 10W-30
Below 5° C (-15°)
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 13
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— INSTRUMENTATION
Start Switch
CAUTION :
Push this switch to start the engine (electric start only). If a
recoil starter is used, pull the starter rope to start the engine.
Make sure the operation switch is in the ON position (up),
otherwise engine will not start.
When using a combination of dual
receptacles, total load should not exceed
the rated capacity of the generating.
Full Power Switch
Power Outlets
The unit is provided with a full power switch. Figures 2 and
3 show simplified wiring diagrams of the dual voltage system.
The generator has the following 120/240 volt 60 Hz (single-
phase) receptacles.
When the full power switch is in the 120 volt (up) position,
you can take up full rated power of the generator at 120
volts from the single duplex receptacle, single locking type
120 volt receptacle, or a combination of these receptacles
as long as the total load does not exceed the generating set
capacity.
z
Single Phase
One Duplex NEMA (GFCI) 5-20R (120V, 20 Amp)
One Twist Lock NEMA L5-30R (120V, 30 Amp)
One Twist Lock NEMA L6-20R (240V, 20 Amp)
Main Circuit Breaker (2-Pole 120/240V 60 Hz)
This 2-pole 21 amp breaker protects the generator from short
circuiting or overloading from the 120/240V 60 Hz single
phase load.
Idle Control Switch
This unit is provided with an automatic idle control for noise
suppression and reduced fuel consumption. The automatic
idle control automatically engages under a no-load condition.
With the automatic idle control switched “ON”, the engine
revolutions will automatically drop to about 2500 rpm (low-
speed operation) within 3 seconds after the load stops.When
the operation is resumed, the engine speed is automatically
increased to about 3600 rpm (high-speed operation) as soon
as the load is connected.
Figure 2. 120 V Simplified Diagram (Switch Up)
NOTE
When the full power switch is in the 120 volt
position, the locking type 240 volt receptacle
cannot be used.
When the full power switch is in the 240 volt (down) position,
you can take up to half of the rated power of the generating
set at 120 volts from the duplex receptacle and up to half of
the rated power of the set at 120 volts from the locking type
120 volt receptacle; or full rated power of the set at 240
volts from the locking type 240 volt receptacle.
Fuel Gauge
The fuel gauge is located on the fuel tank and allows easy
monitoring of the fuel level.
ACVoltmeter
This voltmeter indicates (with a mark) the rated 60 Hz,
single phase output voltage. In addition the voltmeter can
also be used as a diagnostic tool.
If the voltmeter indicator (needle) is below the rated voltage,
engine problems may exist (low/high RPM's). To prevent
damage to the generator or power tools turn the generator
OFF and consult your authorized Multiquip service dealer.
Operation Switch
Figure 3. 120/240V Simplified Diagram (Sw Dn.)
This switch must be in the ON position (up) for normal
operation.
PAGE 14 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— LOAD APPLICATION
Single Phase Load
CAUTION:
Motors and motor-driven equipment draw
much greater current for starting than
during operation.
Always be sure to check the nameplate on the generator
and equipment to insure the wattage, amperage and
frequency requirements are satisfactorily supplied by the
generator for operating the equipment.
Generally, the wattage listed on the nameplate of the
equipment is its rated output. Equipment may require 130—
150% more wattage than the rating on the nameplate, as
the wattage is influenced by the efficiency, power factor and
starting system of the equipment.
An inadequate size connecting cable which cannot carry
the required load can cause a voltage drop which can burn
out the appliance or tool and overheat the cable.
The idle control is operated at minimum load capacity of
100W. If the load capacity is less than 100W, throw the idle
control switch to the OFF position.
NOTE
If wattage is not given on the equipment's
name plate, approximate wattage may be
determined by multiplying nameplate
voltage by the nameplate amperage.
WATTS = VOLTAGE x AMPERAGE
To determine the running wattage for your load, multiply the
running wattage as indicated by steps 1, 2, and 3 below:
1. INCANDESCENT LOADS
Lights, heaters and similar appliances.
Total the running wattage and multiply by 1.
Example:
29 light bulbs @ 100W each = 2.9 KW
use a 3 KW generator.
2. SMALL MOTORS
Drills and other small power tools.
Total the running wattage and multiply by 2.
Example:
A 1 inch drill runs at 1 KW
use a 2 KW generator.
3. LARGE MOTORS
Submersible pumps, table saws etc.
Total the running wattage and multiply by 3.
Example:
A conveyor belt runs at 8 KW
use a 24 KW generator.
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 15
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— OPERATING INSTRUCTIONS
Before Starting
Warm up
1. Be sure to disconnect the electrical load and switch the
main circuit breaker to the “OFF”position prior to starting
the engine.
1. When the engine starts, open the choke slowly.
2. Run the engine at low speed for 3 minutes without load
until the engine warms up.
2. Never start the engine with the main circuit breaker “ON”.
3. Turn the idle control switch to the "OFF" (down) position
and check the voltage by referring to the voltmeter on
the control box.
3. Check the lubricating oil level prior to starting the engine.
Make sure the generator is level. The oil level must be
maintained between two notches on the dipstick.
CAUTION:
4. When there is not enough lubricating oil, fill the crankcase
with high grade motor oil. Use a high quality detergent
oil classified SC, SD or SE. (See Table 3 on page 13)
DO NOT change the engine speed control
lever which has been set at the factory prior
to shipping.
CAUTION:
z
NEVER start the engine when the oil level
is below the lower mark on the dipstick.
1. Check the generator for abnormal noise and smells.Then
connect the load to the receptacles of the generator.
z
Check the fuel level on the fuel gauge.
When fuel is low, fill the fuel tank with
clean fresh unleaded automotive gasoline.
2. Switch the main circuit breaker to the “ON” position and
turn the idle control switch to the “ON” (down) position
for normal (load) engine operation.
z
If gasoline spillage occurs, completely
wipe up the spilled gasoline.
Operation
Check the voltage by referring to the voltmeter on the control
box. When the voltmeter indicates 120 volts, 120 volts from
the 120V receptacles and 240 volts from the 240V receptacle
can be obtained at the same time. Refer to Figure 1, Controls
and Indicators, item 6 on page 10.
Starting
1. Open the fuel cock located below the fuel tank.The fuel
starts to flow when the fuel cock lever is turned
downward.
2. Place the idle control switch in the “ON” (up) position.
3. Close the choke. Adjust the opening of the choke valve
according to operating conditions. When the engine is
warm or the air temperature is high, close the choke
valve halfway or open it all the way.
Stopping the Engine
CAUTION:
NEVER stop the engine suddenly while
running at high speeds.
4. Confirm that the main circuit breaker on the generator
control box is “OFF”.
5. Set the operation switch to the “ON” position and grasp
the starting rope and slowly pull it out. The resistance
becomes hardest at a certain position, corresponding
to the compression point. Rewind the rope a little from
that point and pull out sharply.
1. Remove the load from the generator. Place the circuit
breaker in the “OFF” position. Refer to Figure 1, item 1
on page 10. Run the engine (no-load) with the idle control
switch set to the ON position for three to five minutes,
then stop the engine.
6. If the engine fails to start, repeat the procedure.
CAUTION:z
2. Turn the START/STOP switch to the “STOP” position.
3. Close the fuel cock.
DO NOT pull the starter rope all the way
to the end.
z
DO NOT release the starter rope after
pulling. Allow it to rewind as soon as
possible.
PAGE 16 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— MAINTENANCE
General Inspection
Service Daily
At least daily or prior to each use, the generating set should
be cleaned and inspected for deficiencies. Check for loose,
missing or damaged nuts, bolts or other fasteners. Also check
for fuel or oil leaks.
If engine is operating in very dusty and dry grass conditions.
A clogged air cleaner will result in high fuel consumption,
loss of power and excessive carbon buildup in the
combustion chamber.
Engine Side (Refer to the Engine Instruction Manual)
Cleaning the Fuel Strainer
Check Oil Level
Clean the fuel strainer if it contains dust or water. Remove
dust or water in the strainer cap and wash it in gasoline.
Securely fasten the fuel strainer cap so that fuel will not
leak. Check the fuel strainer every 200 hours of operation or
once a month.
Check the crankcase oil level prior to each use, or when the
fuel tank is filled. Make sure the generating set is level.The
oil level must be between the two notches on the dipstick.
Changing Oil
Spark Plug
Change oil after the first 20 hours of operation. Drain and
refill the engine crankcase every 50 operating hours or once
a week thereafter.Drain crankcase oil into a suitable container
while engine is still warm.Replace the drain plug tightly.Add
oil through the filler hole.
Remove carbon build-up on the spark plug (Figure 4) with a
wire brush. Set the spark plug gap to 0.6—0.7mm (0.024-
0.028 inch).Tighten with a spark plug socket wrench. Clean
the spark plug every 50 operating hours or once a week.
Air Cleaner
Every 50 hours: Remove air cleaner element (std. or heavy
duty types), and wash in kerosene or liquid detergent and
hot water. Wrap foam element in a cloth and squeeze dry.
Wipe heavy duty paper element dry with toweling. Saturate
element with kerosene; squeeze excess from foam element.
Wipe excess from heavy duty paper element.
Figure 4. Spark Plug Gap
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 17
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— PREPARATION FOR LONG -TERM STORAGE
Generator Storage
For storage of the generating set for over 30 days, the
following is required:
z
z
Drain the fuel tank completely.
Run the engine until the gasoline in the carburetor is
completely consumed.
z
z
z
z
Completely drain the oil from the crankcase and refill
with fresh oil.
Remove the spark plug, pour 2 or 3 cc of SAE 30 oil
into the cylinder and crank slowly to distribute the oil.
Slowly rotate the engine a few times with the starter
Rope and install a new plug.
Pull out the starter rope slowly and stop at the
compression point.
z
z
Clean all external parts of the generating set with a cloth.
Cover the generating set and store in a clean, dry place.
PAGE 18 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ—WIRING DIAGRAM
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 19
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ—TROUBLESHOOTING (ENGINE)
diagnosis based on the Engine Troubleshooting (Table 4)
information shown below and on the proceeding page. If the
problem cannot be remedied, please leave the unit just as it
is and consult our company's business office or service
plant.
Practically all breakdowns can be prevented by proper
handling and maintenance inspections, but in the event of a
breakdown, please take a remedial action following the
TABLE 4. ENGINE TROUBLESHOOTING
SYMPTOM
POSSIBLE PROBLEM
SOLUTION
Inspect carburetor to see if fuel
is reaching it?
Check fuel line
No Fuel?
Add Fuel
Water in fuel tank?
Fuel filter clogged?
Stuck carburetor?
Spark plug is red?
Flush or replace fuel tank.
Replace fuel filter
Check float mechanism.
Poor starting
Spark plug is fouled. Check tranistor ignition unit.
Insufficient compression, injected air leaking. Carburetor jets are
clogged (overflow).
Spark plug is blue-white?
No spark present at tip of spark
plug?
Tranistor ignition unit broken, high voltage cord cracked or broken.
Start/Stop switch broken. Replace spark plug if fouled.
No oil?
Add oil as required.
Oil pressure alarm lamp blinks
upon starting?
Check Automatic shutdown circuit "oil sensor".
Replace cylinder and piston and if necessary axel joint.
Tighten cylinder head connecting bolts.
Engine will not turn over?
Cylinder head connecting bolts
loose?
Cylinder head gasket damaged?
Malfunction of valve seat?
Spark plug is loose?
Replace cylinder head gasket.
Re-seat valves.
Insufficient power output "no
compression"
Replace spark plug.
Replace piston rings.
Worn piston rings?
Malfunction in air-cleaner system,
air filter clogged?
Clean or replace air filter.
Air leaking in from interface
between carburetor and cylinder
head?
Tighten bolts between carburetor and cylinder head. Replace
cylinder head gasket.
Insufficient power output
"compression"
Clean or replace fuel filter.
Clean or replace carburetor.
Check carburetor float.
Malfunction in fuel system?
PAGE 20 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ—TROUBLESHOOTING (ENGINE)
TABLE 4. ENGINE TROUBLESHOOTING (CONTINUED)
SYMPTOM
POSSIBLE PROBLEM
Malfunction in cooling fan?
Air in-take filter clogged?
SOLUTION
Check or replace cooling fan.
Insufficient power output
"compression" and overheats
Clean or replace air in-take filter.
Over accumulation of exhaust
products?
Clean and check valves.
Check muffler, replace if necessary.
Burns to much fuel
Wrong spark plug?
Replace spark plug with manufactures suggested type spark plug.
Lubricating oil is wrong viscosity? Replace lubricating oil with correct viscosity.
Exhaust color is continiously
"WHITE"
Worn rings?
Replace rings
Air cleanner clogged?
Clean or replace air cleaner.
Adjust choke valve to the correct position.
Choke valve has not been set to
the correct position?
Exhaust color is continiously
"BLACK"
Carburetor defective, seal on
carburetor broken?
Replace carburetor or seal.
Adjust carburetor.
Poor carburetor adjustment
"engine runs too rich?
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 21
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ—TROUBLESHOOTING (GENERATOR)
diagnosis based on the GeneratorTroubleshooting (Table 5)
information shown below and on the preceding page. If the
problem cannot be remedied, please leave the unit just as it
is and consult our company's business office or service
plant.
Practically all generator breakdowns can be prevented by
proper handling and maintenance inspections, but in the event
of a breakdown, please take a remedial action following the
TABLE 5. GENERATOR TROUBLESHOOTING
SYMPTOM
Low voltage
POSSIBLE PROBLEM
Engine speed too low?
SOLUTION
Raise engine speed to rated RPM.
AC voltmeter not working?
Replace AC voltmeter.
Control box internal wiring
malfunction?
Check control box wiring.
Defective ignition coil?
Check red and green ignition wires. Replace ignition wires if
necessary.
Low voltage. Engine speed
normal 3650 RPM (unloaded),
2500 RPM (idle)
Rotor winding malfunction?
Stator winding malfunction?
Leakage breaker malfunction?
Full power switch malfunction?
Engine speed too high?
Check or replace rotor.
Check or replace stator.
Check or replace CB1.
Check full power switch and full power switch circuit.
Lower engine speed to rated RPM.
Check control box wiring.
Voltage output too high.
Voltage output too high. Engine
speed normal 3650 RPM
(unloaded), 2500 RPM (idle)
Control box internal wiring
malfunction
Circuit breaker will not turn on
"NO LOAD"
Defective circuit breaker?
Replace circuit breaker.
Overload?
Reduce load or replace breaker.
Check load circuit for short.
Check solenoid.
Circuit breaker will turn on
"LOADED" but trips immediately.
Load circuit is shorted?
Stuck solenoid?
Does not accelerate from low to
high "NO LOAD"
Bad Idle control switch?
Idle control switch malfunction?
Check or replace idle control switch.
Check or replace idle control switch.
Does not accelerate from low to
high "LOAD ACTIVE"
Idle control device malfunction?
Check or replace idle control device.
Check control box wiring.
Control box interal wiring
defective?
PAGE 22 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ—TROUBLESHOOTING (GENERATOR)
TABLE 5. GENERATOR TROUBLESHOOTING (CONTINUED)
SYMPTOM
POSSIBLE PROBLEM
Defective rotor windings?
Defective solenoid?
SOLUTION
Check or replace rotor.
Check or replace solenoid.
Does not decelerate no
"VOLTAGE OUTPUT".
Defective idle control device?
Defective solenoid?
Check or replace idle control device.
Check or replace idle control device.
Does not decelerate but has
"VOLTAGE OUTPUT".
Control box wiring malfunction?
Check control box wiring, replace any defective components.
Defective solenoid?
Check or replace solenoid.
Idle control device malfunction?
Check or replace idle control device.
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 23
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— EXPLANATION OF CODE IN REMARKS COLUMN
How to read the marks and remarks used in this parts
book.
Items Found In the “Remarks” Column
Serial Numbers-Where indicated, this indicates a serial
number range (inclusive) where a particular part is used.
Model Number-Where indicated, this shows that the
corresponding part is utilized only with this specific model
number or model number variant.
Items Found In the “Items Number”Column
All parts with same symbol in the number column, , #,
, belong to the same assembly or kit.
+
, %, or
*
■
NOTE
If more than one of the same reference number is
listed, the last one listed indicates newest (or latest)
part available.
NOTE
The contents of this catalog are
subject to change without notice.
PAGE 24 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— SUGGESTED SPARE PARTS
GA-6HZ 1 TO 5 UNITS WITH HONDA
GX340K1EDN2 ENGINE
1 to 5 Units
Qty.
P/N
Description
5 ............ 9807955846......... SPARK PLUG
1 ............ 15510ZE2W01..... OIL LEVEL SWITCH
1 ............ 15600735700 ...... DIPSTICK
1 ............ 28400ZEZW01ZB RECOIL STARTER
5 ............ 17211899000 ...... ELEMENT AIR
1 ............ 16100ZEZF00 ..... CARBURETOR ASSY.
1 ............ 16950ZB4015 ...... FUEL COCK ASSY.
5 ............ 0810107103......... FUEL FILTER
2 ............ 0810106004......... CAP, FUEL TANK
2 ............ 0601805327......... CIRCUIT BREAKER
3 ............ 0601823204......... RECTIFIER
2 ............ 0601812597......... RECEPTACLE
2 ............ 0601811031......... RECEPTACLE, 125V, 30A
2 ............ 0601811032......... RECEPTACLE, 250V 20A
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 25
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— GENERATOR ASSY.
FAN COVER ASSY.
PAGE 26 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— GENERATOR ASSY.
FAN COVER ASSY.
NO
1
PART NO
7901002403
PART NAME
QTY.
1
REMARKS
ROTOR ASS’Y
1-1
1-2
FIELD COIL
1
0601823207
0601822638
0071706304
7901017014
0801096104
0040010000
7901348903
7901315502
7871315022
7875021513
7871331003
7901316004
0040008000
0041208000
7871329514
0601851760
0010108020
0040008000
RECTIFIER
2
D3SB60 (S)
TNR15G431K
6304 2RUNYCM
SURGE ABSORBER
BEARING
2
1-3
2
1
SET BOLT, ROTOR
SET WASHER, BEARING
SPRING WASHER
ARMATURE ASSY
END BRACKET
END BRACKET
GUIDE PANEL,AIR
COVER
1
3
1
4
1
5
1
6
1
7
1
8
1
9
1
10
11
12
13
14
15
SET BOLT, STATOR
SPRING WASHER
PLAIN WASHER
GROMMET
4
4
4
1
CAP
1
OB-13
HEX. HEAD BOLT
SPRING WASHER
4
4
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 27
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— CONTROL BOX ASSY.
CONTROL BOX ASSY.
PAGE 28 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— CONTROL BOX ASSY.
CONTROL BOX ASSY.
NO
1
PART NO
PART NAME
QTY.
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
6
6
1
1
1
1
1
1
2
3
3
5
4
1
REMARKS
UP TO S/N.5125596
FROM S/N.5125597
7901810203
7901810213
0601850102
0601823204
7901850004
7901820103
7901820113
7900501712
0601800258
0601804819
4341817004
0027104010
0601812597
0601811035
0601811032
0027104010
0207004000
0601830737
0601830727
0601830737
0602100102
0601815109
0601823853
0027104010
0601823204
0027103020
0017105016
0017106016
0601802137
CONTROL BOX
CONTROL BOX
2
3
4
5
GROMMET
HOSE
GROMMET
CONTROL PANEL
CONTROL PANEL
NAMEPLATE
UP TO S/N.5125596
FROM S/N.5125597
N-5615B
6
7
AC VOLTMETER 0~120V, 0~240
CIRCUIT BREAKER, 21A
BRACKET, CIRCUIT BREAKER
MACHINE SCREW
RECEPTACLE,5-20R (GFCI)
RECEPTACLE, L5-30R, 125V, 30A
RECEPTACLE,L6-20R, 250V, 20A
MACHINE SCREW
HEX. NUT
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
FULL POWER SWITCH
IDLE CONTROL SWITCH
OPERATION SWITCH
STARTER SWITCH
GROUND TERMINAL
SLOW DOWN UNIT
MACHINE SCREW
RECTIFIER, S5VB60
MACHINE SCREW
HEX. HEAD BOLT
HEX. HEAD BOLT
FUSE, 10A
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 29
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— PIPE FRAME ASSY.
PIPE FRAME ASSY.
PAGE 30 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— PIPE FRAME ASSY.
PIPE FRAME ASSY.
NO
1
PART NO
PART NAME
QTY.
1
1
1
2
4
2
4
2
2
2
1
1
6
1
2
1
1
1
1
2
2
2
2
1
1
2
1
1
1
2
2
2
2
REMARKS
7905413102
7905413112
7905443003
3015419604
0207008000
1725419214
0207008000
0017108030
0017108040
0207008000
7915455103
7855455003
0017106016
7905456104
0017106016
7905512002
0810106004
0810107103
0602125031
7855525514
7855525604
0017108030
0017108020
0605511087
0605513140
0605515096
PIPE FRAME
PIPE FRAME
BASE
TO S/N 5125596
FROM S/N 5125597
2
3
4
5
6
7
8
RUBBER SUSPENSION
HEX NUT
RUBBER SUSPENSION
HEX NUT
HEX. HEAD BOLT
HEX. HEAD BOLT
HEX, NUT
9
COVER
COVER
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
HEX. HEAD BOLT
STOPPER
HEX. HEAD BOLT
FUEL TANK
CAP, FUEL TANK
FUEL FILTER
FUEL GAGE
RUBBER CUSHION
COLLAR
HEX. HEAD BOLT
HEX. HEAD BOLT
FUEL COCK
HOSE
HOSE BAND
BATTERY
BATTERY SHEET
BATTERY BAND
BATTERY BOLT
WING NUT
SPRING WASHER
PLAIN WASHER
HONDA 16950-ZB4-015
HONDA 950001-4519040
1702202104
7905458103
0805082204
0037806000
0040006000
0041206000
32
33
7905467003 PANEL, HEAT INSULATOR
0017106016 HEX, HEAD BOLT
1
2
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 31
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— MUFFLER ASSY.
MUFFLER ASSY.
PAGE 32 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ— MUFFLER ASSY.
MUFFLER ASSY.
NO
1
PART NO
PART NAME
MUFFLER
PROCTER, MUFFLER
PROCTER, MUFFLER
SEAL
QTY.
1
REMARKS
7912310003
0602302001
0602302002
0602302003
0602313060
0602322060
0017106012
0602320175
0602322061
7905461004
001708020
7905460004
0017108025
0207008000
0017108020
7905469004
0017106020
0017106012
7905468004
7905468014
001706020
2
1
HONDA 18320-ZC2-000
HONDA 18325-ZB4-000
HONDA 18329-ZB4-000
HONDA 18335-ZB4-630
HONDA 90183-671-003
3
1
4
2
5
ARRESTOR, SPARK
TAPPING SCREW
HEX. HEAD BOLT
GASKET
1
6
1
7
5
8
1
HONDA 18333-ZB4-800
HONDA 95700-08020-00
9
HEX. HEAD BOLT
BRACKET
2
10
11
12
13
1
HEX. HEAD BOLT
BRACKET
1
1
HEX. HEAD BOLT
HEX, NUT
2
2
14
15
16
17
18
HEX. HEAD BOLT
BRACKET
2
1
HEX. HEAD BOLT
HEX. HEAD BOLT
BRACKET
1
2
1
UP TO S/N 5125596
FROM S/N 5125597
BRACKET
HEX. HEAD BOLT
1
19
4
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 33
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ — NAMEPLATE AND DECALS
NAMEPLATE AND DECALS
PAGE 34 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6HZ — NAMEPLATE AND DECALS
NAMEPLATE AND DECALS
NO
1
PART NO
PART NAME
DECAL : GROUND
QTY.
1
REMARKS
S-1123
S-3704
S-4605
N-5615B
S-5015
S-3311
S-3627
S-4461
S-4984
S-4985
0800628504
1980680004
7900638204
7900501712
7900631302
0820610804
0820610404
7900636004
8700611804
8700611904
2
DECAL : FUEL COCK
DECAL : OPERATING INSTRUCTIONS
DECAL : MQ GA-6HZ
DECAL : MQ 6000
1
3
1
4
1
5
1
6
DECAL : CAUTION
DECAL : WARNING
1
7
1
8
DECAL : OPERATE AT 3600 RPM ONLY
DECAL : WARNING
1
9
1
10
DECAL : DANGER
1
SEE ADDITIONAL DECAL ILLUSTRATIONS ON PAGE 7.
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 35
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER HEAD
HONDA GX240K1 ENGINE — CYLINDER HEAD
CYLINDER HEAD ASSY.
PAGE 36 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER HEAD
CYLINDER HEAD ASSY.
NO
1
PART NO
PART NAME
QTY.
REMARKS
122AOZF6W00
12204ZE2325
12205ZE2315
12216ZE2300
12251ZE3W00
12310ZE2010
12391ZE2010
18330ZE3700
18333ZE3800
90014ZE2000
90042ZE3700
90047ZE2000
90441ZE2010
9405008000
9430112200
957251008000
9807955846
9807955855
HEAD COMP., CYLNDER ...........1.......... INCLUDES ITEM W/
*
2
GUIDE, IN. VALVE (OVER SIZE) 1
*
*
3
GUIDE, EX. VALVE (OVER SIZE) 1
*
4
CLIP, VALVE GUIDE
GASKET, CYLINDER HEAD
COVER COMP., HEAD
PACKING, HEAD COVER
PIPE, EX.
2
1
1
1
1
1
1
2
2
5
6
7
8
9
GASKET, EX. PIPE
BOLT, HEAD COVER
BOLT, STUD, 8X98
BOLT, STUD, 8X47
10
11
12
13
14
15
16
17
WASHER COMP., HEAD COVER 1
NUT, FLANGE, 8MM
2
2
4
1
PIN, DOWEL, 12X20
BOLT, FLANGE, 10X80
PLUG, SPARK (BPR5ES NGK)
PLUG, SPARK (W16EPRU ND) 1
1
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 37
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — RECOIL STARTER
RECOIL STARTER ASSY.
PAGE 38 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — RECOIL STARTER
RECOIL STARTER ASSY.
NO
1
PART NO
PART NAME
QTY.
1
REMARKS
INCLUDES ITEMS W/
28400ZE3W01ZB
28410ZE3W01ZB
28421ZE3W01
28422ZE2W01
28441ZE2W01
28442ZE2W01
28443ZE2W01
28444ZE2W01
28445ZE2W01
28461ZE2W01
28462ZE3W01
28469ZE2W01
90004ZE2W01
957010600800
STARTER ASSY, RECOIL
CASE COMP., RECOIL STARTER
PULLEY, RECOIL STARTER
RATCHET, STARTER
SPRING, FRICTION
SPRING, STARTER RETURN
SPRING, RATCHET
RETAINER, SPRING
HOLDER, SPRING
GRIP, STARTER
*
2
1
*
3
1
*
4
2
*
5
1
*
6
1
*
7
2
*
8
1
*
9
1
*
10
1
*
11
12
13
14
ROPE, RECOIL STARTER
GRID REINFORCEMENT
SCREW, CENTER
1
*
*
*
1
1
BOLT, FLANGE, 6X8
3
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 39
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FAN COVER
FAN COVER ASSY.
PAGE 40 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FAN COVER
FAN COVER ASSY.
NO
1
PART NO
PART NAME
COVER COMP., FAN
SHROUD
GROMMET, DRAIN HOLE
BOLT, FLANGE, 6X12
CLIP
QTY.
REMARKS
19610ZE3700ZB
19631ZE3W00
81329567020
90013883000
90654SA4003
1
1
1
6
2
2
3
4
5
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 41
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CAMSHAFT/VALVES
CAMSHAFT/VALVES ASSY.
PAGE 42 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CAMSHAFT/VALVES
CAMSHAFT/VALVES ASSY.
NO
1
PART NO
PART NAME
QTY.
REMARKS
14100ZE3010
14410ZE3013
14431ZE2000
14441ZE2000
14451ZE1003
14568ZE1000
14711ZE3000
14721ZE3000
14751ZE2003
14771ZE2000
14773ZE2000
14775ZE2010
14781ZE2000
14791ZE2010
90012ZE0010
90206ZE1000
CAMSHAFT ASSY. .............................. 1 ........ INCLUDES ITEMS/W
*
2
ROD, PUSH
ARM, VALVE ROCKER
LIFTER, VALVE
2
2
2
2
1
1
1
2
1
1
2
1
1
2
2
3
4
5
PIVOT, ROCKER ARM
SPRING, WEIGHT RETURN
VALVE, IN
6
*
7
8
9
VALVE, EX.
SPRING, VALVE
10
11
12
13
14
15
15
RETAINER, IN. VALVE SPRING
RETAINER, EX. VALVE SPRING
SEAT, VALVE SPRING
ROTATOR, VALVE
PLATE, PUSH ROD GUIDE
BOLT, PIVOT
NUT, PIVOT ADJUSTING
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 43
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — PISTON/RINGS
PISTON/RINGS ASSY.
PAGE 44 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — PISTON/RINGS
PISTON/RINGS ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
13010ZE3003
13011ZE3003
13012ZE3003
13013ZE3003
13101ZE3W00
13102ZE3W00
13103ZE3W00
13104ZE3W00
13111ZF6000
13200ZE3010
90001ZE8000
90601ZE3000
RING SET, PISTON (STD)
RING SET, PISTON (0.25)
RING SET, PISTON (0.50)
RING SET, PISTON (0.75)
PISTON (STD)
1
1
1
1
1
1
1
1
1
2
PISTON (0.25)
PISTON (0.50)
PISTON (0.75)
3
4
5
PIN, PISTON
ROD ASSY., CONNECTING ............ 1 .. INCLUDES ITEM W/
*
BOLT, CONNECTING ROD
CLIP, PISTON PIN, 18MM
2
2
*
6
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 45
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — AIR CLEANER
AIR CLEANER ASSY.
PAGE 46 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — AIR CLEANER
AIR CLEANER ASSY.
NO
1
PART NO
PART NAME
TUBE BREATHER
ELEMENT, AIR CLEANER
SEPARATOR, AIR CLEANER
CASE COMP., AIR CLEANER
STAY, AIR CLEANER
QTY. REMARKS
15721ZB4000
17211899000
17212ZB4003
17220ZB4003
17222ZC2000
17231899000
17235899000
17236899000
17252899000
17367413690
9405005000
9405006000
1
1
1
1
1
1
2
2
1
1
6
3
2
3
4
5
6
COVER COMP., AIR CLEANER
CLIP A, AIR CLEANER WIRE
CLIP B, AIR CLEANER WIRE
SEAL, AIR CLEANER
7
8
9
10
11
12
FILTER, DRAIN TUBE
NUT, FLANGE, 5 MM
NUT, FLANGE, 6 MM
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 47
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER BARREL
CYLINDER BARREL ASSY. (RECOIL STARTER)
PAGE 48 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER BARREL
CYLINDER BARREL ASSY. (RECOIL STARTER)
NO
1
PART NO
PART NAME
QTY. REMARKS
12000ZE3816
15510ZE2043
16541ZE3000
90131883000
90446KE1000
9410912000
91201ZE3004
91203952771
91353671004
9405010000
9425108000
957010601200
961006202000
BARREL ASSY., CYLINDER
SWITCH ASSY., OIL LEVEL
SHAFT, GOVERNOR ARM
BOLT, DRAIN PLUG
WASHER, 8.2X17X0.8
WASHER, DRAIN PLUG
OIL SEAL
1
1
1
2
1
2
1
1
1
1
1
2
1
2
3
4
5
6
7
8
OIL SEAL
9
ORING, 14 MM
10
11
12
13
NUT, FLANGE, 10 MM
PIN, LOCK, 8 MM
BOLT, FLANGE, 6X12
BEARING, RADIAL BALL 6202
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 49
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER BARREL
CYLINDER BARREL ASSY. (ELECTRIC START)
PAGE 50 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CYLINDER BARREL
CYLINDER BARREL ASSY. (ELECTRIC START)
NO
1
PART NO
PART NAME
QTY. REMARKS
12000ZE3826
15510ZE2043
16541ZE3000
90131883000
90446KE1000
9410912000
91201ZE300
91203952771
91353671004
9405010000
9425108000
957010601200
961006202000
BARREL ASSY., CYLINDER
SWITCH ASSY., OIL LEVEL
SHAFT, GOVERNOR ARM
BOLT, DRAIN PLUG
WASHER, 8.2X17X0.8
WASHER, DRAIN PLUG
OIL SEAL
1
1
1
2
1
2
1
1
1
1
1
2
1
2
3
4
5
6
7
8
OIL SEAL
ORING, 14 MM
9
10
11
12
13
NUT, FLANGE, 10 MM
PIN, LOCK, 8 MM
BOLT, FLANGE, 6X12
BEARING, RADIAL BALL 6202
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 51
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CRANKCASE COVER/GOVERNOR
CRANKCASE COVER/GOVERNOR ASSY.
PAGE 52 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CRANKCASE COVER/GOVERNOR
CRANKCASE COVER/GOVERNOR ASSY.
NO
1+
2
3
4
5
6
7#
8*+
9*+
10*+
11*+
12*+
13*+
14*+
15
16+
17*
18
19+
20+
21#
PART NO
PART NAME
QTY. REMARKS
06165ZE3000
11300ZE3020
11381ZE3800
15600735700
15621896010
15625ZE1000
16510ZE3000
16511ZE8000
16512ZE3000
16513ZE2000
16531ZE2000
16520ZG4910
90473147000
90602ZE1000
91201ZE3004
9410106800
GOVERNOR KIT ..................................... 1 ...... INCLUDES ITEM W/*
COVER ASSY., CRANKCASE ................. 1 ...... INCLUDES ITEM W/+
PACKING, CASE COVER
CAP ASSY., OIL FILLER ......................... 1 ...... INCLUDES ITEM W/#
PACKING, OIL FILLER CAP
PACKING, OIL FILLER CAP
GOVERNOR ASSY.
WEIGHT, GOVERNOR
HOLDER, GOVERNOR WEIGHT
PIN, GOVERNORWEIGHT
SLIDER, GOVERNOR
CAP, OIL FILLER
WASHER, 6X16
CLIP, GOVERNOR HOLDER
OIL SEAL, 35X52X8
WASHER, PLAIN, 6 MM
PIN, DOWEL, 8X12
BOLT, FLANGE, 8X40
BEARING, RADIAL BALL 6202
BEARING, RADIAL BALL 6207
CAP, OIL FILLER
1
1
1
1
3
1
3
1
1
1
1
1
1
2
7
1
1
1
90701HC4000
959000804000
961006202000
961006207000
15620735700
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 53
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FLYWHEEL/FAN ASSY.
FLYWHEEL/FAN ASSY.
PAGE 54 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FLYWHEEL/FAN ASSY.
FLYWHEEL/FAN ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
19511ZE3000
28451ZE3W01
31100ZE3721
90201ZE3790
90741ZE2000
FAN, COOLING
PULLEY, STARTER
FLYWHEEL COMP.
NUT, SPECIAL, 16 MM
KEY, SPECIAL WOODRUFF
1
1
1
1
1
2
3
4
5
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 55
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — COIL ASSY.
COIL ASSY.
PAGE 56 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — COIL ASSY.
COIL ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
30500ZE2013
30700ZE1013
31510ZE1811
31511ZE3000
31512ZE2000
36101ZE3800
36103ZE1000
90012888000
90013883000
90015883000
COIL ASSY., IGNITION
CAP ASSY., NOISE SUPPRESSO
COIL ASSY., LAMP 12V/25W
CLAMP, WIRE
1
1
1
1
1
1
1
4
1
2
2
3
4
5
GROMMET, CORD
6
CORD, STOP SWITCH
HOLDER, STOP SWITCH CORD
BOLT, FLANGE, 6X40
BOLT, FLANGE, 6X12
BOLT, FLANGE, 6X28
7
8
9
10
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 57
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CRANKSHAFT ASSY.
CRANKSHAFT ASSY.
PAGE 58 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CRANKSHAFT ASSY.
CRANKSHAFT ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
13310ZE3701
13351ZE3010
13352ZE3310
14311ZE3310
961006207000
CRANKSHAFT COMP. ..................... 1 ....INCLUDES ITEMS W/
*
2
WEIGHT, BALANCER
GEAR, BALANCER DRIVE
GEAR, TIMING
1
1
1
1
3
*
4
*
5
BEARING, RADIAL BALL, 6207
*
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 59
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — ELECTRIC STARTER ASSY.
ELECTRIC STARTER ASSY.
PAGE 60 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — ELECTRIC STARTER ASSY.
ELECTRIC STARTER ASSY.
NO
PART NO
PART NAME
QTY. REMARKS
1
1
1
31204ZA0003
31206ZE3003
31207ZE3013
31201ZE3013
31211ZE2003
31212ZE3003
31213ZE2003
31215ZE2003
31218ZE3003
31219ZE2003
31222ZE3791
31231ZE2003
31232ZE3003
31233ZE2003
90110ZE2003
91601ZE2003
938920501418
938920503218
9407206080
CONTACTOR ASSY,
*
*
2
ARMATURE COMP
*
3
CLUTCH COMP, OVER RUNNING . 1 ....INCLUDES ITEMS W/
#
*
4
MOTOR UNIT, STARTER ................ 1 ....INCLUDES ITEMS W/
5
BRAKET, CENTER
BRAKET, FR
1
1
1
2
1
4
1
1
1
1
1
1
1
4
2
2
*
6
*
7
GEAR, DRIVE DINION
BRUSH
*
8
*
9
YOKE COMP
*
10
SPRING, BRUSH RETURN
GEAR, REDUCTION
HOLDER, BRUSH
WIRE, WATER COVER
INSULATOR
*
11
12
13
14
15
16
17
18
19
20
#
*
*
*
*
*
*
*
*
*
SCREW-WASHER, 4X6
PACKING
SCREW-WASHER, 5X14
SCREW-WASHER, 5X32
NUT-WASHER, 6MM
BOLT, FLANGE, 8X35
957010803508
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 61
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — GOVERNOR CONTROLS ASSY.
GOVERNOR CONTROLS ASSY.
PAGE 62 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — GOVERNOR CONTROLS ASSY.
GOVERNOR CONTROLS ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
16550ZE3700
16555ZE3000
16561ZE3000
16562ZE3700
16570ZE3700
16584883300
90013883000
90015ZE5010
93500050350A
9405006000
ARM, GOVERNOR
ROD, GOVERNOR
SPRING, GOVERNOR
SPRING, THROTTLE RETURN
1
1
1
1
2
3
4
5
CONTROL ASSY. ............................. 1 ....INCLUDES ITEMS W/
*
6
SPRING, CONTROL ADJUSTING
BOLT, FLANGE, 6X12
1
1
1
1
1
*
7
8
9
10
BOLT, GOVERNOR ARM
SCREW, PAN, 5X35
*
NUT, FLANGE, 6MM
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 63
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CARBURETOR ASSY.
CARBURETOR ASSY.
PAGE 64 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — CARBURETOR ASSY.
CARBURETOR ASSY.
NO
PART NO
PART NAME
GASKET SET
QTY. REMARKS
1
16010ZE3701
16011ZA0931
16013ZA0931
16015ZA0931
16016ZH7W01
16024124761
16028ZA0931
16100ZE3F10
16124ZE0005
16148141881
16166ZE3701
16211ZE3700
16221ZE3800
16223ZE3800
16230ZE3701
16260ZE2722
16261ZE2702
16262ZE2711
16263ZA0000
16264ZE2701
16265ZE2721
16268ZE2721
16269ZA0800
16400ZE2703
16611ZE2711
16613893000
16615893000
36135ZV1003
53149964003
90431ZE2700
90432ZE2700
90433ZE2700
90434ZE2700
90650SD9003
93500050120A
938920501208
9405006000
1
1
1
1
1
1
1
*
2
VALVE SET, FLOAT
FLOAT SET
*
3
*
4
CHAMBER SET, FLOAT
SCREW SET
*
5
6
SCREW SET, DRAIN
SCREW SET
*
7
*
8
CARBURETOR ASSY. ..................... 1 ... INCLUDES ITEMS W/
*
9
SCREW, THROTTLE STOP
CAP, CHOKE DUST
1
1
1
1
1
1
1
*
10
*
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
NOZZLE, MAIN
INSULATOR, CARBURETOR
PACKING, CARBURETOR
PACKING, INSULATOR
VALVE ASSY., SOLENOID
*
STAY, MANUAL CHOKE ................... 1 .. INCLUDES ITEMS W/
#
#
#
#
#
#
#
STAY, COMP., SOLENIOD
LEVER, CHOKE
1
1
1
1
1
1
2
1
1
1
1
1
1
1
2
1
1
1
2
2
2
1
1
1
1
4
1
1
1
1
JOINT, ROD
ROD, CHOKE
STOPER, CHOKE ROD
SPRING, MANUAL CHOKE
PACKING, AIR CLEANER
DIAPHRAGM ASSY.
ROD, CHOKE CONTROL
GROMMET, CHOKE ROD
GUIDE, CHOKE ROD
VALVE, DASHPOT CHECK
BUSH, ARM PIVOT
WASHER, CHOKE LEVER
SEAL, CHOKE LEVER
WASHER, THRUST
COLLAR, LOVER
#
#
#
#
#
#
#
#
#
CLIP, WIRE HARNESS
SCREW, PAN, 5X12
SCREW, WASHER 5X12
NUT, FLANGE, 6MM
WASHER, PLAIN 5MM
E-RING 2MM
#
*
#
#
#
#
9410305000
9454002010
9454004010
E-RING 4MM
9454007010
E-RING 7MM
9500202070
CLIP B7, TUBE
950053507510
950053513010
99101ZF50920
99101ZF50950
TUBE, 3.5X75
TUBE, 3.5X130
JET, MAIN, #92
*
JET, MAIN, #95
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 65
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — SOLENOID ASSY.
SOLENOID ASSY.
PAGE 66 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — SOLENOID ASSY.
SOLENOID ASSY.
NO
1
PART NO
PART NAME
QTY. REMARKS
16268893000
17850ZD1E30
36160ZB4003
93500050080A
90013883000
SPRING, CHOKE RETURN
LEVER COMP., THROTTLE
SOLENOID ASSY.
1
1
1
2
1
2
3
4
SCREW, PAN
BOLT, FLANGE, 6X2
5
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 67
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FUEL COCK ASSY.
FUEL COCK ASSY.
PAGE 68 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
HONDA GX340K1 ENGINE — FUEL COCK ASSY.
FUEL COCK ASSY.
NO
PART NO
PART NAME
PACKING, FUEL STRAINER CUP
QTY. REMARKS
1
COCK ASSY., FUEL ......................... 1 ..... INCLUDES ITEMS W/
1
16173001004
16950ZB4015
16952ZB4005
16958397771
16959471831
16967GA6671
90854ZB2000
950014521040
9500202080
*
2
*
3
SCREEN, FUEL STRAINER
O-RING
FILTER CUP
CUP, FUEL STRAINER
RUBBER, FUEL TUBE
TUBE, FUEL, 4.5X210
CLIP B8, TUBE
1
1
1
1
1
1
2
*
4
*
5
*
6
*
7
8
9
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 69
Download from Www.Somanuals.com. All Manuals Search And Download.
Effective: July 1, 2000
TERMS AND CONDITIONS OF SALE — PARTS
PRICINGANDREBATES
4. Freight is at the sender’s expense. All
partsmustbereturnedfreightprepaidto
Multiquip’sdesignatedreceivingpoint.
PAYMENT TERMS
Prices are subject to change without prior
notice.Pricechangesareeffectiveonaspecific
dateandallordersreceivedonorafterthatdate
willbebilledattherevisedprice. Rebatesfor
price declines and added charges for price
increaseswillnotbemadeforstockonhandat
thetimeofanypricechange.
Terms of payment for parts are net 10 days.
5. Parts must be in new and resalable
condition,intheoriginalMultiquippackage
(ifany),andwithMuiltiquippartnumbers
clearlymarked.
FREIGHTPOLICY
All parts orders will be shipped collect or
prepaidwiththechargesaddedtotheinvoice.
All shipments are F.O.B. point of origin.
Multiquip’sresponsibilityceaseswhenasigned
manifesthasbeenobtainedfromthecarrier,
andanyclaimforshortageordamagemustbe
settledbetweentheconsigneeandthecarrier.
6. Thefollowingitemsarenotreturnable:
Multiquip reserves the right to quote and sell
directtoGovernmentagencies,andtoOriginal
Equipment Manufacturer accounts who use
our products as integral parts of their own
products.
a. Obsolete parts. (If an item is listed
inthepartspricebookasbeing
replaced by another item, it is
obsolete.)
b. Any parts with a limited shelf life
(such as gaskets, seals, “O” rings,
andotherrubberparts)thatwere
purchasedmorethansixmonths
priortothereturndate.
MINIMUMORDER
SPECIALEXPEDITINGSERVICE
TheminimumchargeforordersfromMultiquip
is $15.00 net. Customers will be asked for
instructionsregardinghandlingofordersnot
meetingthisrequirement.
A$20.00to$50.00surchargewillbeaddedto
theinvoiceforspecialhandlingincludingbus
shipments, insured parcel post or in cases
where Multiquip must personally deliver the
partstothecarrier.
c. Anylineitemwithanextendeddealer
netpriceoflessthan$5.00.
d. Special order items.
RETURNEDGOODSPOLICY
e. Electricalcomponents.
Returnshipmentswillbeacceptedandcredit
will be allowed, subject to the following
provisions:
LIMITATIONSOFSELLER’SLIABILITY
f.
Paint,chemicals,andlubricants.
Multiquip shall not be liable here under for
damagesinexcessofthepurchasepriceofthe
itemwithrespecttowhichdamagesareclaimed,
andinnoeventshallMultiquipbeliableforloss
of profit or good will or for any other special,
consequentialorincidentaldamages.
g. Decalsandpaperproducts.
h. Itemspurchasedinkits.
1. AReturnedMaterialAuthorizationmust
beapprovedbyMultiquippriortoshipment.
7. Thesenderwillbenotifiedofanymaterial
receivedthatisnotacceptable.
2. ToobtainaReturnMaterialAuthorization,
alistmustbeprovidedtoMultiquipParts
Sales that defines item numbers,
quantities,anddescriptionsoftheitemsto
bereturned.
8. Such material will be held for 5 working
days from notification, pending
instructions. If a reply is not received
within5days,thematerialwillbereturned
tothesenderathisexpense.
LIMITATIONOFWARRANTIES
a. Thepartsnumbersanddescriptions
mustmatchthecurrentpartsprice
list.
Nowarranties,expressorimplied,aremadein
connection with the sale of parts or trade
accessories nor as to any engine not
manufacturedbyMultiquip.Suchwarranties
made in connection with the sale of new,
complete units are made exclusively by a
statement of warranty packaged with such
units, and Multiquip neither assumes not
authorizes any person to assume for it any
other obligation or liability whatever in
connectionwiththesaleofitsproducts.Apart
fromsuchwrittenstatementofwarranty,there
arenowarranties,express,impliedorstatutory,
which extend beyond the description of the
productsonthefacehereof.
9. Creditonreturnedpartswillbeissuedat
dealer net price at time of the original
purchase,lessa15%restockingcharge.
b. The list must be typed or computer
generated.
10. In cases where an item is accepted for
which the original purchase document
can not be determined, the price will be
basedonthelistpricethatwaseffective
twelvemonthspriortotheRMAdate.
c. Thelistmuststatethereason(s)for
thereturn.
d. The list must reference the sales
order(s)orinvoice(s)underwhich
theitemswereoriginallypurchased.
11. Credit issued will be applied to future
purchasesonly.
e. Thelistmustincludethenameand
phonenumberoftheperson
requestingtheRMA.
3. A copy of the Return Material
Authorizationmustaccompanythereturn
shipment.
PAGE 70 — GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04)
Download from Www.Somanuals.com. All Manuals Search And Download.
NOTE PAGE
GA-6HZ A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #4 (10/08/04) — PAGE 71
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS AND OPERATION MANUAL
HERE'S HOW TO GET HELP
PLEASE HAVE THE MODEL AND SERIAL NUMBER
ON-HAND WHEN CALLING
PARTS DEPARTMENT
800-427-1244 or 310-537-3700
FAX: 800-672-7877 or 310-637-3284
SERVICE DEPARTMENT/TECHNICAL ASSISTANCE
800-478-1244 or 310-537-3700
FAX: 310- 537-4259
WARRANTY DEPARTMENT
888-661-4279, or 310-661-4279
FAX: 310- 537-1173
MAIN
800-421-1244 or 310-537-3700
FAX: 310-537-3927
Manufactured for MULTIQUIP INC.
by
DENYO MANUFACTURING CO., JAPAN
MULTIQUIP INC.
POST OFFICE BOX 6254
CARSON, CA 90749
310-537-3700 • 800-421-1244
FAX:310-537-3927
WWW:multiquip.com
Atlanta • Boise • Dallas • Houston • Newark
Quebec, Canada • Manchester, UK • Rio De Janiero, BR • Guadalajara, MX
Download from Www.Somanuals.com. All Manuals Search And Download.
|